Professional ac repair services for homes and businesses in Superior and surrounding Wisconsin communities.
KIC Refrigeration delivers expert air conditioning repair in Superior, WI, diagnosing compressor failures, refrigerant leaks, frozen evaporator coils, and electrical faults using superheat, subcooling, and amp draw measurements. Our EPA Section 608 certified technicians restore rated SEER output through manufacturer-guided repair procedures across all major AC brands.
Properties throughout Superior (pop. 26,532) face unique demands when it comes to ac repair. Wisconsin heating loads, cooling calculations, and the insulation levels and duct configurations found in Superior homes all influence the approach we take. KIC Refrigeration tailors every ac repair project to the conditions your property actually faces — no generic solutions.
Choosing the right contractor for ac repair in Superior, WI makes all the difference between efficient comfort and a system that short-cycles. KIC Refrigeration uses Manual J load calculations, installs to manufacturer specifications, and backs every project with a warranty. Call (866) 858-2961 to schedule your free assessment.
How our NATE-certified technicians deliver quality ac repair results from start to finish.
KIC Refrigeration begins every AC repair in Superior, WI with a systematic assessment. We verify 24-volt control voltage at the thermostat, check high and low voltage wiring for damage, inspect the disconnect for burned contacts, confirm the breaker is properly sized, and visually inspect both indoor and outdoor units before powering up the system for testing.
At your Superior property, our technician tests the run and start capacitors with a capacitance meter, checks the contactor for pitting and voltage drop, measures compressor amperage against rated load amps, and reads suction and discharge pressures to calculate superheat and subcooling against the manufacturer charge chart for current conditions.
We replace the failed component — capacitor, contactor, fan motor, compressor, or metering device — using parts rated for your system. For refrigerant leaks, we locate the leak, repair or replace the leaking component, evacuate, and recharge the system by weight.
KIC Refrigeration verifies every AC repair in Superior, WI with a comprehensive performance test. We confirm temperature split, superheat, subcooling, compressor amperage, condenser fan amperage, blower CFM, and thermostat operation. We document all readings and explain the results before we consider the job complete.
Get answers to the ac repair questions our customers ask most often.
AC repair in Superior typically costs $150 to $500 for common component failures including run capacitors ($150 to $250), contactors ($150 to $350), condenser fan motors ($250 to $500), and blower motors ($300 to $600). Compressor replacement is the most expensive repair at $1,500 to $3,500 depending on unit tonnage and whether the system uses R-410A or older R-22 refrigerant. Evaporator coil replacement runs $800 to $2,500 including the refrigerant recovery and recharge. KIC Refrigeration provides a detailed written estimate with itemized parts and labor costs before beginning any AC repair at your Superior property so there are no surprises on the invoice.
Most AC repairs in Superior are completed in 1 to 2 hours during a single service visit. Capacitor and contactor replacements are quick fixes that take 15 to 30 minutes of hands-on time. Fan motor and blower motor replacements take 1 to 2 hours including wiring and testing. Compressor replacement is the most time-intensive repair at 3 to 6 hours because it requires refrigerant recovery with an EPA-certified machine, compressor removal, new compressor installation, nitrogen-purged brazing, pressure testing at 300 PSI, evacuation to below 500 microns, and recharging by weight. KIC Refrigeration arrives at your Superior home with a fully stocked truck to complete most repairs in a single visit.
An AC that runs but produces little or no cooling is most commonly caused by low refrigerant charge from a leak, which reduces the suction pressure and causes the evaporator coil temperature to drop below 32 degrees, forming ice that blocks airflow completely. Other causes include a dirty condenser coil that cannot reject heat, a failed compressor that runs but does not pump refrigerant, a stuck or failed metering device — either a TXV or fixed orifice — that restricts refrigerant flow, or a blower motor running at reduced speed due to a failing capacitor. KIC Refrigeration connects manifold gauges at your Superior home and measures suction pressure, discharge pressure, superheat, and subcooling to diagnose the exact cause.
AC refrigerant recharge in Superior costs $200 to $500 for R-410A systems at roughly $50 to $80 per pound, and $400 to $1,200 for older R-22 systems at $80 to $150 per pound due to the phaseout-driven supply shortage. However, simply adding refrigerant without finding the leak is a temporary and wasteful fix — the charge will leak out again in weeks or months and you will be back in the same situation. KIC Refrigeration always locates the leak first using electronic leak detectors and UV dye, repairs the leaking component, evacuates the system to remove moisture and air, and recharges by weight to the manufacturer specification. This approach fixes the problem permanently.
Our reputation is built on certified technicians, honest pricing, and results that last.
"Good experience with the furnace tune-up. Technician was thorough and pointed out a couple things to watch for. Only reason for four stars is scheduling took a few days."
"Mini split repair was done right the first time. The outdoor unit had a refrigerant leak and they found it, fixed it, and recharged the system same day."
"These guys are the real deal. Boiler was making a terrible noise and they diagnosed the problem in minutes. Runs perfectly now."